Download TR-710 - Jotron

USERS MANUAL
TR-710
www.jotron.com
EC Declarations of Conformity,
available at www.jotron.com
Read this Users Manual fully to familiarise yourself with
the equipments functions and facilities.
Abbreviations and definitions
DEFAULT
A condition that the navigator assumes automatically if no other
condition is initiated by the operator.
IEC
International Electro-technical Commission.
IMO
International Maritime Organization
IP rating
Joint factor (to indicate the waterproofing of the equipment)
ITU
International Telecommunication Union.
LED
Light Emitting Diode.
VHF
Very High Frequency -A set of frequencies in the MHz region.
VSWR
Voltage standing wave ratio.
99213_UM_TR710_D
Amendment Record
AMENDMENT
NO.
INCORP.
BY
DATE
PAGE(S)
VERSION
REASON FOR
CHANGE
1
07.04.05
7,8
A
EM4418
2
07.04.05
8
B
EM4440
3
07.04.05
17,18,22
C
EM4461
05.02.07
all
D
Kontroll med med
manualer.doc
4
ES
5
6
7
8
9
10
11
12
13
14
15
99213_UM_TR710_D
3
I MPORTANT BATTERY INFOR M A TI ON FOR TR-710 M A NPACK
The battery pack is of NiMH type. To get the most out of your
battery pack and avoid technical problems, a few precautions should
be taken.
4
1.
Always switch the TR-710 “OFF” when charging the
battery. Disconnect the charger before switching the
TR-710 “ON”.
2.
Always charge the battery to full charge when charging.
Avoid charging under 0°C or over + 40°C.
3.
All rechargeable batteries lose charge while stored. The rate
is dependent on the temperature. When stored at 25°C a
fully charged battery will have more than 50% capacity
after a few months, while at 45°C it might be down at 50%
after approx one month.
4.
If the battery has been totally discharged or stored for a long
time, the charger may terminate before full charge is
reached. In this case do as follows:
• Switch OFF the TR-710 and connect the charger for a few
minutes.
• Disconnect the charger, switch the TR-710 “ON”, and
press PTT a few times.
• Switch the TR-710 ”OFF” and connect the charger again.
5.
Never short-circuit, solder, reverse charge, crush,
disassemble or incinerate the battery.
This may result in fire, explosion and severe burn hazard.
99213_UM_TR710_D
CONTENT:
1.
2.
INTRODUCTION....................................................... 6
General information...................................................................................
6
What comes with the three versions of TR-710........................................
6
Precautions and warnings..........................................................................
7
Technical specifications.............................................................................
8
OPERATING INSTRUCTIONS.................................... 9
General operation ...................................................................................... 11
Menus ........................................................................................................ 12
3.
Appendix A
99213_UM_TR710_D
TR-710 Menu Flowchart ..................... 20
5
1. INTRODUCTION
General information
The Jotron TR-710 represent the latest generation of Jotron Multiuse Radio
Transceivers. The radio operates at the airband 118-137 MHz with chooseable
channel spacing, 8.33 KHz, 12.5 KHz or 25 KHz. The radiotransceiver operates in
accordance to ICAO recommendations and conforms to the requirements of
European Telecom Standard Institute, ETSI, EN 300676 standard. The transceiver
will be delivered with 10 watt, 40 watt PEP, output power. The transceiver will be
supplied as 3 main versions.
What comes with the three versions of TR-710
Mobile Radio TR-710 M
• Hand microphone
• Desk top bracket
• Antenna
• Operators manual
Man-pack Radio TR-710 MP
• Shoulder bag
• Hand microphone
• Battery pack
• Battery charger
• Antenna
• Operators manual
Marine Desktop Radio TR-710 MD
• Hand microphone
• Power supply (230/110V)
• Desk top bracket
• Antenna adapter
• Operators manual
6
99213_UM_TR710_D
Precautions and warnings
Batteries
The batteries are rechargeable NiMh type with a capacity of 12V/4500mAh.
The following should be noticed:
• Do not short-circuit, solder, crush, disassemble or incinerate the battery pack.
This may result in fire, explosion and severe burn hazard.
• Avoid charging batteries below 0°C or above 40°C.
Connectors and cables
When handling connectors and cables, notice the following warnings:
• Do not force plugs in place, as this may damage the pins in the plugs.
• Do not pull the cables when removing connectors from the TR-710, take instead
a firm grip around the connector and pull.
Display and front panel
Avoid touching the display with sharp objects. Scratches can reduce the visibility.
Storage and safe handling
Operating temperature is from -20°C to +55°C. Cleaning of the equipment can be
done with a cloth soaked in a mixture of ordinary dish-detergent and water.
When the radio is used intensive the cooling rib will be very hot.
99213_UM_TR710_D
7
Technical specifications
Frequency range:
Channel separation:
Frequency steps:
Preset channels:
Type of modulation:
Monitor:
Antenna connector:
Operating temperature:
Storage temperature:
Operating voltage:
118 - 137 MHz.
25 kHz, 12.5 / 8.33 kHz. (Selectable)
25 kHz, 12.5 / 8.33 kHz
63
AM (A3E)
In headphone and rear connector
50Ω, TNC-connector
-20 to + 55°C
-20 to + 70°C.
230/115 VAC ± 10% (external power supply)
11-15VDC
13.7VDC nominal
Output power is reduced at lower voltages
Power consumption:
10W, 80% modulation: < 50VA
Battery package:
Dimension:
Weight:
Hours of operation:
12VDC, 4500mAh NiMh
8 cm (H) x 21 cm (W) x 22 cm (D)
1.8 kg, (2.9 kg with battery)
Dutycycle 10/90% 10W (mode M and MD) 6.5 hours.
2.5W (mode MP) 8.5 hours.
Output power:
Sensitivity:
10W. Adjustable. (40W PEP)
10 dB SINAD at 1µV pd, 30 % modulation
8
99213_UM_TR710_D
2. OPERATING INSTRUCTIONS
TR-710 has an interface
that is easy to use,
with a self-explanatory
graphical display.
Figure A: Keyboard
and display, TR-710.
1 Power ON/OFF.
Turns the TR-710 on and off. Has to be pushed for more than 1 sec. to power
off, in order to prevent unwanted operation.
2 Graphical LCD (Liquid Crystal Display).
The graphical display gives the user information about the frequency, menu settings, choices and status. The graphical LCD has backlighting, making it easy
to see in the dark.
3 Battery Indicator
Indicate the status of the battery, four steps. The indicator flash when the battery
is close to empty. The battery indicator is only visible in Man Pack (MP) mode.
4 Control Wheel.
For changing frequency, channels, volume, squelch and adjusting selected values up and down.
5 Function keys.
For moving through menus and adjusting selected values up and down.
6 Connector for headset or hand-held microphone with PTT button.
A headset or hand-held microphone can be connected here. The connector will
also supply a headset which need a voltage supply.
99213_UM_TR710_D
9
Transceiver rear connections
Figure B: Rear view, TR-710.
1 Antenna Connector.
TNC-connector for antenna input/output.
2 Power-supply Connector.
This connector is connected to the external DC supply (+11 to +15V).
3 Multifunction Connector.
For details refer to technical handbook.
Power supply connector
Figure C: Power supply connector, female.
Table 1: functional description of the power
supply connector.
Pin pair nr.
Signal
1
U_BAT
2
GND
Function description
Supply voltage (11-15V)
Common ground.
Table 1:
10
99213_UM_TR710_D
General operation
There is a menu wheel on the right side of the display. The wheel has three different functions:
• Volume control.
• Squelch control.
• Maneuvering in menus and changing of values.
STANDARD SCREEN
This is the standard mode for the transceiver. In this mode the menu wheel automatically adjust the volume and when it is operated the display gives a graphical
volume indication. The display returns to the standard screen after a break of more
than two seconds. A push on the menu wheel gives the squelch function and the
next push, or a break of more than three sec, will return to the volume function.
By pressing the function keys the user gets access to several functions and menus.
A flowchart of the menu is shown in appendix A.
When a menu is selected, the menu wheel changes its function to menu maneuvering. When submenus are entered the wheel can be used to adjust the actual value.
The maneuvering in menus, and changing of values, can also be carried out by the
arrows (function keys). The display automatically returns to the standard screen
after a break of more than 30 seconds.
If the operator wants to adjust the volume or squelch when a menu is entered, one
push gives the volume function, the next gives the squelch function and the third
push gives the value adjustment.
Pressing the function key "ENTR" enters the actual menu, new values and settings
are also stored by pressing "ENTR".
99213_UM_TR710_D
11
To escape or return to a higher level, push "CANCEL" (function key).
If the microphone is fitted with an internal loudspeaker the function TX SIDE
TONE has to be set OFF to avoid feedback.
Menus
PREV – Fast selection of channels
Select between present and previous channel by pushing the function key
"PREV".
BITE – Built In Test Equipment
This function menu will measure and display the parameters shown in table 2.
Table 2 indicates the limits for acceptable values for these parameters. If the limits
are exceeded an alarm will be displayed.
Measurement Normal
Min
Max
Temp PA
-
-20 °C
+95 °C
Fwd Power
1W – 2,5W – 5W – 8W –10W
Ref Power
Depends on the antenna and forward power
10W
0
The level of
forward power.
U Battery
Depends on the power source
10.3 V
15 V
9 Volt
9V
8,5 V
10 V
5 V Dig
5V
4,3 V
5,6 V
5V analog
5V
4,3 V
5,6 V
3 Volt
3V
2,7 V
3,3 V
Current
0,4 A in receive
0,3 A
5 A (transmitting)
Modulation
-
0%
100%
IF Current
6 mA
LNA Current
24.5 mA
10 mA
30 mA
RSSI
1.1 V at 1 uV
-
-
Temp LCD
A few degrees above the ambient temperature -20°C
+55°C
Table 2:
12
99213_UM_TR710_D
CH –Selection of channels
Channel
Select from the preset channels.
Maximum preset channels: 63
MENU – Main Menu
The Main-menu consist of a receiver-menu,
transmitter-menu and a general-menu.
99213_UM_TR710_D
13
Rx menu - Receiver menu
NOISE BLANK
ON/OFF
When the function is ON radar and pulse noise
will be detected and blanked out
AUDIO AGC
ON/OFF
Automatic gain control of the audio amplifier.
When the function is ON the gain will be adjusted automatically to keep the audio level of the
received signal constant.
OPEN SQ
ON/OFF
Equivalent as setting the squelch level to zero.
When the function is ON the Squelch will be
open. This function can also be activated by
pressing the function key "OPEN", that is displayed when the squelch menu is activated by
pressing the menu wheel.
14
99213_UM_TR710_D
Tx menu - Transmitter menu
MODULATION
Range 10 – 100 %
Sets the modulation factor of the transmitter.
AGC
ON/OFF
Automatic gain control.
When the function is ON the output level will be
kept constant.
AGC MODE
SLOW/FAST
Adjust the time constant of the AGC function.
99213_UM_TR710_D
15
MUTE
ON/OFF
When the function is ON the transmitter will
mute low audio signals.
INPUT
MIC/LINE
Select between microphone input or line input.
When line input is selected, "LINE" is shown in
the standard screen picture.
(Line is used for remote operation).
TX POWER
Adjust the output power of the transmitter.
Range: 1 to 10 watt, (40 w PEP).
Steps: 10, 25, 50, 80, and 100 %.
TIME OUT
This function set the maximum time for how
long the transmitter can be keyed continuously.
Range: 0.5 – 5 minutes, steps of 30 seconds.
This function can also be turned off.
16
99213_UM_TR710_D
General - General menu
LCD CONTRAST
Adjust the contrast in the display.
Range: 19 - 62 %.
LCD LIGHT
Adjust the intensity of the display.
Range: OFF, 1, 2, 3.
99213_UM_TR710_D
17
PANEL LIGHT
Light inside the keyboard on/off.
ON/OFF
FREQUENCY
Frequency range: 118.000 MHz to 136.975 MHz.
The frequency is changed in steps of 25 kHz,
8.33 / 12.5 kHz optional.
STORE CHANNEL
Select channel, the actual frequency will be stored on this channel by pressing ENTR.
DELETE CHANNEL
elect channel, the actual channel will be deleted
on this channel when pressing ENTR.
>25kHz
25kHzSTEP
STEP OFF
OFF<
18
25kHz STEP
ON/OFF
Select 25kHz step ON or OFF and press ENTR to
save.
99213_UM_TR710_D
AF OUT
LS+HP/LS/HP/EXT
Select between internal Loudspeaker (LS),
Headphone (HP) or External loudspeaker (EXT).
If the microphone is fitted with an internal loudspeaker, this can be activated by choosing HP.
TX SIDETONE
ON/OFF
When the function is ON the operator can hear
his own voice in the headphone when transmitting.
If the microphone is fitted with an internal loudspeaker the function has to be set OFF to avoid
feedback.
ACKNOW.BEEP OFF/SHORT/NORM/LONG
Set the length/intensity of the beep for each
time the function keys are operated.
MANPACK MODE
ON/OFF
Set the following parameters:
Forward power = 25 % /2.5 w.
Set the battery symbol in the display.
Turn off the radio automatically when the battery voltage is lower than 10.3 Volt.
Default
CANCEL/ENTER
Restore default settings.
When choosing ENTR all settings except frequencies and channels will be set to default
values.
99213_UM_TR710_D
19
Appendix A
TR-710 MENU FLOWCHART
20
99213_UM_TR710_D
99213_UM_TR710_D
21
22
99213_UM_TR710_D
99213_UM_TR710_D
23
NOTES:
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
24
99213_UM_TR710_D
NOTES:
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
99213_UM_TR710_D
25
NOTES:
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
...........................................................................................................
26
99213_UM_TR710_D
Jotron AS
P.O. Box 54, NO-3280 Tjodalyng, Norway
Tel: +47 33 13 97 00 | Fax: +47 33 12 67 80
www.jotron.com