Download METHYLENE GREEN, ZINC CHLORIDE DOUBLE SALT Safety

METHYLENE GREEN, ZINC CHLORIDE DOUBLE SALT
Safety Data Sheet
Emergency Telephone Number: CHEMTREC 1-800-424-9300
For Information call: DUDLEY 732-886-3100
DUDLEY CORPORATION
125 Kenyon Drive
Lakewood, New Jersey 08701
Effective Date: January 1, 2015
1. PRODUCT IDENTIFICATION: Synonyms: C.I. 52020; 3,7-Bis(Dimethylamino)-4-Nitro-Phenothiazin-5-lum, Chloride
CAS No: 2679-01-8 Molecular Weight: 364.84 Chemical Formula: C16H17CIN4O2S. 1/2ZnCl2
2. HAZARDS IDENTIFICATION: GHS Classification: Not a hazardous substance.
HMIS Classification; Health hazard: 0, Flammability: 0, Physical hazards: 0
NFPA Rating: Health hazard: 0, Fire: 0, Reactivity Hazard: 0
Potential Health Effects: Eyes: May cause eye irritation. Skin: May cause skin irritation.
Ingestion: May be harmful by ingestion Inhalation: May be harmful by inhalation.
3. COMPOSITION, INFORMATION ON INGREDIENTS:
Chemical Name
CAS No.
Methylene Green, Zinc Chloride Double Salt
2679-01-8
Percent
90-100
Hazardous
No
4. FIRST AID MEASURES: Inhalation: Remove to fresh air. If not breathing, give artificial respiration. If breathing is
difficult, give oxygen. Call a physician. Ingestion: If swallowed, wash out mouth with water, provided person is
conscious. Call a physician immediately. Skin Exposure: Remove any contaminated clothing. Wash skin with soap or
mild detergent and water for at least 15 minutes. Get medical attention if irritation develops or persists.
Eye Exposure: Wash eyes with plenty of water for at least 15 minutes. Assure adequate flushing by separating the
eyelids with fingers. Get medical attention immediately.
5. FIRE FIGHTING MEASURES: General Information: Not considered to be a fire or explosion hazard under normal
conditions. Wear self-contained breathing apparatus and protective clothing to prevent contact with skin and eyes.
Special Hazards Arising: Carbon oxides, Nitrogen oxides, Sulfur oxides, HCl gas.
Extinguishing Media: Water Spray, Carbon Dioxide, Dry Chemical Powder or alcohol-resistant foam.
6. ACCIDENTAL REALEASE MEASURES: General Information: Wear proper PPE as required.
Spills: Vacuum or sweep up material and place into a suitable disposal container. Hold for waste Disposal. Avoid raising
dust. Ventilate area and wash spill site after material pickup is complete.
7. HANDLING AND STORAGE: Handling: Avoid breathing dust, vapor, mist, or gas. Avoid contact with skin and eyes.
Storage: Store in a tightly closed container. Protect container from physical damage. Store in a cool, dry ventilated area
from sources of heat or ignition.
8. EXPOSURE CONTROLS, PERSONAL PROTECTION: Engineering Controls: Facilities storing or utilizing this material
should be equipped with an eyewash facility and safety shower. Use adequate ventilation.
Chemical Name
ACGIH
NIOSH
OSHA-Final/Vacated PELs
Methylene Green, Zinc Chloride Double Salt None listed
None listed
None listed
Personal Protective Equipment: Eyes: Wear chemical safety goggles Skin: Rubber gloves, and Rubber boots.
Clothing: Wear appropriate protective clothing. Wear a chemical apron.
Respirators: Wear NIOSH/MSHA-Approved respirators.
9. PHYSICAL AND CHEMICAL PROPERTIES: Appearance: Black State: Powder Odor: None Solubility: Soluble in water.
Boiling Point: No data Melting Point: No data Vapor Density & Pressure: No data Evaporation Rate: No data
10. STABILITY AND REACTIVITY: Stability: Stable. Hazardous Decomposition Products: see section 5
Incompatibilities: Strong Oxidizing Agents.
11. TOXICOLOGICAL INFORMATION: RTECS#: SP5775000 LD50/LC50: Not available.
Carcinogenicity: CAS# 2679-01-8: Not listed by ACGIH, IARC, NTP, or CA Prop 65.
12. ECOLOGICAL INFORMATION: May cause long-term adverse effects in the aquatic environment.
13. DISPOSAL CONSIDERATIONS: Disposal: Dissolve or mix the material with a combustible solvent and burn in a
chemical incinerator equipped with an afterburner and scrubber. Observe all Federal, State and Local Environmental
Regulations. Chemical waste generators must determine whether a discarded chemical is classified as a hazardous waste.
US EPA guidelines for the classification determination are listed in 40 CFR Parts 261.3. Additionally, waste generators
must consult state and local hazardous waste regulations to ensure complete and accurate classification.
RCRA P-Series: None listed. RCRA U-Series: None listed.
14. TRANSPORT INFORMATION: Not regulated as a hazardous material.
15. REGULATORY INFORMATION:SARA 311/312: None
SARA Section 302 Extremely Hazardous Substances None of the chemicals in this product have a TPQ.
Section 313 No chemicals are reportable under Section 313.
STATE CAS# 2679-01-8 is not present on state lists from CA, PA, MA, MN, FL, or NJ.
California Prop 65: No significant risk level: None of the chemicals in this product are listed.
EUROPEAN/INTERNATIONAL REGULATIONS European Labeling in Accordance with EC Directives
Hazardous Symbols: XN WGK (Water Danger/Protection) CAS#2679-01-8: No information available.
Canada - DSL/NDSLCAS# 2679-01-8 is not listed on Canada’s DSL List.
Canada – WHMIS: Not available. CAS# 2679-01-8 is not listed on Canada’s Ingredient Disclosure List.
16. DISCLAIMER INFORMATION: DUDLEY CORPORATION provides the information herein in good faith but makes no
representation as to its comprehensiveness or accuracy. This document is intended only as a guide to the appropriate
precautionary handling of the material by a properly trained person using this. Individuals receiving the information
must exercise their independent judgment in determining its appropriateness for a particular purpose. DUDLEY
CORPORATION makes no representations or warranties, either expressed or implied, including without limitation and
warranties of merchantability, fitness for a particular purpose with respect to the information set forth herein or to the
product to which the information refers. Accordingly, DUDLEY CORPORATION will not be responsible for damages
resulting from the use of or reliance upon this information.