Download BPX500.1 - GiveFile.net

BPX500.1
2 CHANNEL
POWER AMPLIFIER
SERVICE MANUAL
JBL Consumer Products
250 Crossways Park Dr.
Woodbury, New York 11797
Rev1
2/2004
Power Amplifier
BPX500.1
CONTENTS
Specifications………………………….…………………..……1
Features…………………………………………………………2
Test Conditions And Notes……………………………………2
Controls/connections…………………………………..………3
Mounting…………………………………………….…..………3
Applications………………………………………..……………4
Typical System Configuration…………………………………5
Troubleshooting……………………………………….……..…6
PCB drawings……………………………………..……………7
Electrical Parts List……………………………………………10
Mechanical Parts List……………….………………..………13
Block Diagrams……………………………………….………14
Semiconductor Pinouts………………………………………15
Exploded view…………………………………………………20
Schematics……………………………………………….……21
Packing………………………………….………………………30
SPECIFICATIONS
Power Output, 4 Ohms:
n/a
Power Output, 2 Ohms:
250W x 2
Power Output, Bridged, 4 Ohms:
500W x 1
Power Output, Parallel, 1 Ohm:
500W x 1
MIN. Speaker Impedance:
1 ohm
Frequency Response:
20Hz~320Hz, -3dB
Input Sensitivity (RCA type):
250mV~6V
THD + Noise (4 Ohms):
0.5%
Signal-to-Noise:
93 dB
Maximum Current Draw:
50A
Fuse Replacement:
30Ax2
External Dimensions:
Length
12 ¼” (312mm)
Width
13” (330mm)
Depth
2 9/16” (66mm)
JBL continually strives to improve its products. New materials, production methods and design refinements are introduced into existing
models without notice as a routine expression of our design philosophy. For this reason, Power Series Multichannel Automotive
Amplifiers may differ in some respects from their published specifications and descriptions, but will always equal or exceed the original
specifications unless otherwise stated.
1
Power Series Amp OM
5/20/03
10:51 AM
Page 3
Power Amplifier
BPX500.1
APPLICATIONS – BPx MODELS
To the right are several application
diagrams to help plan your subwoofer
system installation. Figures 1 through 3
show how to configure the JBL Power
Series subwoofer amplifiers (models
BPx500.1, BPx1100.1 and BPx2200.1)
for 2-channel, bridged-mono and
parallel-mono operation
“Setting the uO tput Mode” on page 6).
NOTE: For simplicity, Figures 1 through
3 do not show power, remote and input
connections.
NOTE: If the nominal impedance
of your speaker system is close to
2 ohms, be prepared to try both
bridged and parallel configurations to
determine which performs better.
Set OUTPUT MODE
to 2CH/BR
CH 1
(on input panel)
CH 2
2 CHANNEL
BRIDGED
PARALLEL
BPx Amplifier
2CH/BR
OUTPUT MODE
NEON
PARALLEL*
(partial rear panel)
SPEAKER OUTPUTS
*SEE MANUAL FOR PARALLEL CONNECTION
X-OVER
FREQ
Figure 1. The JBL Power Series
subwoofer amplifier is set to
2-channel mode to drive a pair
of subwoofers.
32Hz 320Hz
12dB 24dB
SLOPE
Subwoofer
Subwoofer
Set OUTPUT MODE
to 2CH/BR
CH 1
(on input panel)
CH 2
2 CHANNEL
BRIDGED
PARALLEL
BPx Amplifier
2CH/BR
OUTPUT MODE
NEON
PARALLEL*
(partial rear panel)
SPEAKER OUTPUTS
*SEE MANUAL FOR PARALLEL CONNECTION
Figure 2. The JBL Power Series
subwoofer amplifier is set to
bridged (mono) mode to drive
a single subwoofer. Use this
mode only when the nominal
impedance of the speaker
system is 2 ohms or greater.
X-OVER
FREQ
32Hz 320Hz
12dB 24dB
SLOPE
Subwoofer (2 ohms or greater)
Set OUTPUT MODE
to PARALLEL
CH 1
(on input panel)
CH 2
2 CHANNEL
BRIDGED
PARALLEL
BPx Amplifier
2CH/BR
OUTPUT MODE
NEON
PARALLEL*
jumper
(partial rear panel)
SPEAKER OUTPUTS
*SEE MANUAL FOR PARALLEL CONNECTION
Figure 3. The JBL Power Series
subwoofer amplifier is set to
parallel mode to drive a single
subwoofer. Use this mode only
when the nominal impedance
of the speaker system is less
than 2 ohms.
X-OVER
FREQ
32Hz 320Hz
12dB 24dB
SLOPE
Subwoofer (less than 2 ohms)
NOTE: A jumper is added
between the + terminals.
4
3
5
BPX500.1
Power Amplifier
TROUBLESHOOTING
SYMPTOM
No audio
(POWER LED
is off)
No audio
(PROTECT LED
flashes every
4 sec.)
No audio
(PROTECT
LED is on)
No audio
(PROTECT
and POWER
LEDs flash)
I-E/OPT LED
is on all times
(not flashing)
No audio
(PROTECT
LED is on)
Distorted audio
Distorted audio
and PROTECT
LED flashes
Music lacks
“punch”
LIKELY CAUSE
No voltage at BATT+
or REM terminals,
or bad or no ground
connection
DC voltage on
amplifier output
Amplifier is
overheated
Voltage less than 9V on
BATT+ connection
Amplifier is being
overdriven
Voltage more than 16V
or less than 8.5V on
BATT+ connection
regulator
Input sensitivity is
not set properly, or
amplifier or source
unit is defective
Short circuit in
speaker or wire
Speakers are not
connected properly
6
SOLUTION
Check voltages at
amplifier terminals
with VOM
Amplifier may need
service; see enclosed
warranty card for
service information
Make sure amplifier
cooling is not blocked
at mounting location;
verify speaker-system
impedance is within
specified limits (see
“Specifications” on the
next page)
Check vehicle
charging system for
defective voltage
regulator
Check INPUT
LEVEL setting;
see previous page
Check vehicle
charging system for
defective voltage
Check INPUT
LEVEL setting; or
check speaker wires
for shorts or grounds
Remove speaker leads
one at a time to locate
shorted speaker or
wire, then repair
Check speaker
connections for
proper polarity
7
8
PAS132-01
REV.0
9
A20K
R701
2K
MOD02
623PCB4-B
623PCB4-B
MOD02
2K
R701
A20K
A20K
R701
2K
MOD02
623PCB4-B
623PCB4-B
MOD02
2K
R701
A20K
A20K
R701
2K
MOD02
623PCB4-B
623PCB4-B
MOD02
2K
R701
A20K
A20K
R701
2K
MOD02
623PCB4-B
623PCB4-B
MOD02
2K
R701
A20K
A20K
R701
2K
MOD02
623PCB4-B
623PCB4-B
MOD02
2K
R701
A20K
PAS132-01
REV.0
PAS132-01
REV.0
PAS132-01
REV.0
PAS132-01
REV.0
PAS132-01
REV.0
VR701
VR701
PAS132-01
REV.0
VR701
VR701
PAS132-01
REV.0
VR701
VR701
PAS132-01
REV.0
VR701
VR701
PAS132-01
REV.0
VR701
VR701
PCB-00-01312
PCB-00-00952
P.C.B
P.C.B
FR-4 DOUBLE LAYER, 2Oz (GREEN)
FR-4 SINGLE LAYER, 1Oz (GREEN)
PAM613-01
PAS132-01
198 X 329 m/m (MAIN)
33 X 33m/m (REMOTE)
ICO-00-00021
ICO-00-00005
ICO-00-00004
I.C
I.C
I.C
SMD PWM "SO-16"
SMD QUAD OP AMP "SO-14"
SMD DUAL OP AMP "SOP-08"
TL494CD
TL074CD
TL072CD
1
1
11
ICO-00-00354
ICO-00-00229
ICO-00-00054
ICO-00-00094
ICO-00-00099
I.C
I.C
I.C
I.C
I.C
SMD REMOTE CONTROL "SSOP-16"
SMD COMPARATOR "SO-14"
SMD DIVIDER "SO-16"
SMD "SOP-08"
SMD 2.5V SHUNT IC "SOT-89"
NJM13600M
B2 (NE529D) / LM361D
F4 (MC14060BD)
KIA393F
KIA431F
U1
U101
U102,103,105,106,108,109,110,112,350,509
U510
U104
U281,481
U611
U2,3,801,901,950
U282,482
DIO-00-00220
DIO-00-00117
DIODE
DIODE
ZENER 12V "CHIP"
SWITCHING SIGNAL "CHIP"
SMAZ12B / PTZ12V
RLS4148
D901
D10,20,181,281,282,283,284,481,482,483
D484,581,725,801,802,909,913,914,915,922
D923,924,925
1
23
TRS-00-00115
TRANSISTOR
HIGH CURRENT NPN "SOT-89"
KTC4373Y
11
TRS-00-00197
TRANSISTOR
HIGH CURRENT PNP "SOT-89"
KTA1661Y
TRS-00-00098
TRS-00-00113
TRANSISTOR
TRANSISTOR
SMALL SIGNAL PNP "SOT-23"
SMALL SIGNAL NPN "SOT-23"
KTA1504GR
KTC3875GR
Q203,205,207,209,281,403,405,407,409,481
Q914
Q1,204,206,208,210,282,404,406,408,410
Q482,916,920
Q3,4,8,9,364
Q2,6,128,362,363,365,611,631,632,705
RES-12-00010
RES-12-00043
RES-12-00262
RES-12-00263
RES-12-00115
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
100 OHM
220 OHM
300 OHM
820 OHM
910 OHM
R204,404
R203,403
R906,952
R116
R202,206,402,406
RES-12-00006
RES-12-00034
RES-12-00252
RES-12-00059
RES-12-00077
RES-12-00264
RES-12-00105
RES-12-00266
RES-12-00011
RES-12-00030
RES-12-00039
RES-12-00054
RES-12-00267
RES-12-00085
RES-12-00093
RES-12-00097
RES-12-00268
RES-12-00269
RES-12-00270
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
SMD"1206" 1/4WF
1.5K OHM
2.2K OHM
2.7K OHM
3.3K OHM
4.7K OHM
5.1K OHM
8.2K OHM
9.1K OHM
10K OHM
18K OHM
20K OHM
27K OHM
33K OHM
47K OHM
51K OHM
56K OHM
91K OHM
110K OHM
300K OHM
R288,488
R113,557
R117
R554
R111,112,177,179,555,556,577,579
R2
R905,951
R805,807
R150,353,354,453,454,591
R118,806
R26
R27
R1
R103,104,105,106,107,108,109,110,904,950
R23
R808
R101,102
R22
R30
RES-12-00147
RES-12-00189
RES-12-00161
RES-12-00123
RES-12-00137
RES-12-00159
RES-12-00162
RES-12-00194
RES-12-00199
RES-12-00203
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
1 OHM
4.7 OHM
22 OHM
100 OHM
150 OHM
220 OHM
240 OHM
470 OHM
510 OHM
560 OHM
R207,208,211,212,407,408,411,412
R5,8
R619,743,744,753,754
R115,282,482,915,922,924,925
R130
R21,603
R151
R174,233,433,574
R123,125
R809
RES-12-00145
RESISTOR
SMD"1206" 1/4WJ
1K OHM
RES-12-00119
RES-12-00121
RES-12-00148
RES-12-00152
RES-12-00185
RES-12-00170
RES-12-00186
RES-12-00187
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
1.5K OHM
1.8K OHM
2.2K OHM
2.7K OHM
3K OHM
3.3K OHM
4.3K OHM
4.7K OHM
RES-12-00198
RES-12-00124
RESISTOR
RESISTOR
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
5.6K OHM
10K OHM
RES-12-00133
RES-12-00138
RES-12-00144
RES-12-00160
RESISTOR
RESISTOR
RESISTOR
RESISTOR
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
12K OHM
15K OHM
18K OHM
22K OHM
R33,183,185,290,351,451,490,583,585,613
R622,742,752
R723,725
R3,153
R6,155,201,205,281,401,405,481
R4,157,363
R173,181,573,581
R600,614
R10,141,142,156
R17,34,114,145,154,180,188,189,287,487
R571,588,589,590,601,726,916
R9,11,143,144
R25,121,124,126,127,132,283,286,289,362
R364,483,486,489,569,570,617,618,724,907
R908,910,911,913,918,920,921,923,929
R602
R7,122,129
R917
R14,16,19,31,32,187,365,587,615
10
1
1
1
2
1
5
2
13
5
10
2
2
2
1
4
2
2
1
1
8
1
2
2
6
2
1
1
1
10
1
1
2
1
1
8
2
5
7
1
2
1
4
2
1
13
2
2
8
3
4
2
4
17
4
29
1
3
1
9
RES-12-00166
RES-12-00175
RES-12-00184
RES-12-00195
RES-12-00213
RES-12-00217
RES-12-00122
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
27K OHM
30K OHM
39K OHM
47K OHM
68K OHM
75K OHM
100K OHM
RES-12-00136
RES-12-00154
RES-12-00158
RESISTOR
RESISTOR
RESISTOR
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
150K OHM
200K OHM
220K OHM
R28,172,572,919
R128
R152
R18,182,186,582,586
R271,471
R160,176,178,560,576,578,801,802
R13,184,224,225,226,229,230,352,424,425
R426,429,430,452,584
R131
R149
R914
RES-12-00146
RES-12-00261
RESISTOR
RESISTOR
SMD"1206" 1/4WJ
SMD"1206" 1/4WJ
1M OHM
1.5M OHM
R12,15,20,24,361,612,616,621,912
R909
CEC-12-00009
CEC-12-00044
CEC-12-00022
CEC-12-00031
CEC-12-00039
CEC-00-00130
CEC-12-00004
CEC-12-00042
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
SMD"1206" 50V 5%
SMD"1206" 50V 5%
SMD"1206" 50V 5%
SMD"1206" 50V 5%
SMD"1206" 50V 5%
SMD"1206" 50V 5%
SMD"1206" 50V 5%
SMD"1206" 50V 5%
10pF
47pF
220pF
330pF
470pF
102pF
103pF
473pF
2
3
1
2
1
5
3
13
CEC-12-00006
CAPACITOR
SMD"1206" 50V 5%
104pF
C105,106
C611,612,617
C726
C616,618
C111
C5,100,110,905,951
C286,486,724
C3,187,188,189,190,191,192,193,194,195
C196,197,198
C8,12,13,14,15,32,93,94,181,182
C201,202,204,205,211,281,282,285,289,290
C291,292,361,363,401,402,404,405,411,481
C482,485,489,490,491,492,613,714,715,721
C722,774,778,874,878,902
ELC-00-00076
ELC-00-00077
ELC-00-00079
CAPACITOR
CAPACITOR
CAPACITOR
ELECTROLYTIC CHIP "MV / SC" (4Dx5H)
ELECTROLYTIC CHIP "MV / SC" (4Dx5H)
ELECTROLYTIC CHIP "MV / SC" (5Dx5H)
1uF/50V
2.2 F/50V
4.7uF/50V
3
4
16
ELC-00-00067
ELC-00-00063
ELC-00-00064
ELC-00-00567
ELC-00-00639
ELC-00-00066
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
ELECTROLYTIC
ELECTROLYTIC
ELECTROLYTIC
ELECTROLYTIC
ELECTROLYTIC
ELECTROLYTIC
10uF/25V
22uF/16V
47uF/16V
100uF/16V
100uF/35V
220uF/16V
C123,801,913
C287,293,487,493
C1,2,4,6,7,11,95,124,283,288
C483,488,614,771,871,908
C353,453
C10,17,101,102,103,104,121,122
C362
C16,777,877,903
C773,873
C631
ELC-00-00619
CAPACITOR
ELECTROLYTIC CHIP "MV-BP / NC" (6.5Dx6H) 22 F/16V
C113,156,173,573
4
DIO-00-00003
DIO-00-00108
DIO-00-00041
DIODE
DIODE
DIODE
RECTIFIER
FAST RECOVERY
ZENER 12V 0.5W
1N4004
FR154
1N5242
D363,701
D771,772,774,871,872,874
D201,202,401,402
2
6
4
RES-00-00018
RES-00-00040
RES-00-00038
RESISTOR
RESISTOR
RESISTOR
CARON FILM 0.5WJ
CARON FILM 0.5WJ
CARON FILM 0.5WJ
10 OHM
22 OHM
220 OHM
R214,215,216,221,222,414,415,416,421,422
R284,285,484,485
R41,42
MYC-00-00020
MYC-00-00019
MYC-00-00034
MYC-00-00045
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
MYLAR 5% 100V
MYLAR 5% 100V
MYLAR 5% 100V
MYLAR 5% 100V
102J
103J
333J
823J
C9,119,245,280,445,480,904,950
C172,255,455,572,602,615
C144
C141,142
MYC-00-00083
MYC-00-00156
MYC-00-00088
MYC-00-00061
MYC-00-00066
MYC-00-00085
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
MYLAR 5% 63V "TL"
MYLAR 5% 63V "TL"
MYLAR 5% 63V "TL"
MYLAR 5% 63V "TL"
MYLAR 5% 63V "TL"
MYLAR 5% 63V "TL"
104J
184J
224J
334J
474J
105J
C265,465,725
C152
C203,206,403,406
C143
C151
C207,209,284,364,407,409,484,702,703,723
C787,788
JUP-00-00045
JUMPER
"0"OHM JUMPER
10m/m
J1,2,3,4,5,6,7,8,9
9
IND-00-00020
INDUCTOR
COIL AXIAL 5%
100uH
L611
1
ELC-00-00254
CAPACITOR
ELECTROLYTIC"SXE"
100uF/25V
C701
1
FET-00-00001
FET-00-00021
FET-00-00037
FET
FET
FET
N-CH MOSFET "TO-220"
P-CH MOSFET "TO-220"
N-CH MOSFET "TO-220"
IRF3205
IRF9640
IRFB31N20D
Q742,743,752,753
Q212,213,214,412,413,414
Q217,218,417,418
4
6
4
ICO-00-00157
ICO-00-00162
I.C
I.C
VOLTAGE REGULATOR +12V 1A
VOLTAGE REGULATOR -12V 1A
KIA7812PI
KIA7912PI
U761
U861
1
1
DIO-00-00152
DIO-00-00048
DIODE
DIODE
FAST RECOVERY
RECTIFIER
YG225D2
1N5404
D761,763
D702
2
1
CHIP "MV / SC" (5Dx5H)
CHIP "MV / SC" (5Dx5H)
CHIP "MV / SC" (6.3Dx5H)
CHIP "MV / SC" (6.3Dx6H)
CHIP "MV / SC" (8Dx10H)
CHIP "MV / SC" (8Dx10H)
11
4
1
1
5
2
8
15
1
1
1
9
1
46
2
8
1
4
2
1
10
4
2
8
6
1
2
3
1
4
1
1
12
TRS-00-00096
TRS-00-00112
TRANSISTOR
TRANSISTOR
VIDEO PNP "TO-126"
VIDEO NPN "TO-126"
A1381
C3503
Q202,402
Q201,401
2
2
RES-00-00800
RESISTOR
CARON FILM 1WJ
2.2K OHM
R901
1
RES-00-01112
RES-00-01046
RES-00-01079
RES-00-01099
RES-00-01073
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
MOR 2WJ SMALL TYPE"FORMING 15m/m"
MOR 2WJ SMALL TYPE"FORMING 15m/m"
MOR 2WJ SMALL TYPE"FORMING 15m/m"
MOR 2WJ SMALL TYPE"FORMING 15m/m"
MOR 2WJ SMALL TYPE"FORMING 15m/m"
2.2 OHM
100 OHM
2.2K OHM
3.9K OHM
47 OHM
R263,463
R761
R246,255,262,446,455,462
R764,765
R245,445
2
1
6
2
2
RES-00-00909
RES-00-00919
RES-00-00916
RESISTOR
RESISTOR
RESISTOR
MOR 3WJ
MOR 3WJ
MOR 3WJ
10 OHM
220 OHM
2.7K OHM
R771,871
R727
R209,210,409,410
2
1
4
RES-00-00947
RESISTOR
SHUNT 5WJ 3P
0.01 OHM
R234,434
2
ELC-00-00087
ELC-00-00282
ELC-00-00092
ELC-00-00035
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
ELECTROLYTIC
ELECTROLYTIC
ELECTROLYTIC
ELECTROLYTIC
ELECTROLYTIC
22uF/100V
100/100V
470uF/63V
2200uF/25V
3300uF/63V
C249,250,252,449,450,452
C901
C208,210,212,213,408,410,412,413
C719,720,727
C781,782
6
1
8
3
2
MYC-00-00198
CAPACITOR
MYLAR 10% 630V "BOX"
222K
C761
1
MYC-00-00076
MYC-00-00109
CAPACITOR
CAPACITOR
MYLAR 10% 100V "BOX"
MYLAR 10% 250V "BOX"
225K
225K
C247,264,447,464,762,763
C768
6
1
COR-TF-00379
TRANSFORMER
44PHI MAGNETICS
3T(0.7X15):11T(0.7X5)+4T(0.7X1) T1
1
COI-00-00086
COI-00-00108
COI-00-00109
INDUCTOR
INDUCTOR
INDUCTOR
RING CORE
FILTER COIL
DRUM COIL
CL-900A
CL-1800A
CL-1600E
L1
L761
L2,3
1
1
2
JUP-00-00003
BAR JUMPER
METAL BAR
35m/m
BJ1,2,3
3
REN-00-00001
RESONATOR
2.56MHz
CSA2.56MG
X611
1
VOL-00-00134
SEMI VOLUME
SEMI H-TYPE (RG06X502)
5K
VR103,503
2
COI-00-00106
CURRENT SENSOR
50A
CCS-50
CT1
1
RCA JACK
GOLD PLATE 4P
KJB554A
RCA101
1
JAC-00-00050
MODULAR JACK
4P
623PCB4-B
MOD1
1
SWI-00-00056
SWITCH
SLIDE SWITCH 4m/m
JSS-2208
SW102,103
2
DIO-00-00198
DIO-00-00277
LED
LED
3PHI BLUE
3PHI RED
HL304H1BC2
HNED-3401L
LED2
LED1,801
1
2
HOD-00-00006
FUS-00-00010
FUSE HOLDER
AUTO FUSE
PCB TYPE
ATC
JSF08031P
30A
F1,2
SET 2 + ACCESSORY 2
2
4
REL-00-00009
RELAY
DC12V,10A
KB11-E12S
REL1,2
2
TER-00-00219
TER-00-00220
TERMINAL
TERMINAL
SPEAKER TERMINAL GOLD PLATED 4P
POWER TERMINAL GOLD PLATED 3P
KTD-9216A
KTD-9218A
TER2
TER1
1
1
VOL-00-00055
VOL-00-00114
VOL-00-00283
VOL-00-00282
VOLUME
VOLUME
VOLUME
VOLUME
V12L5(9X5)G(PH2D)N15KC-15C50Kx4
V12L5(9x5)G)PH2D)N17KC-3B20Kx2
V12L5(9x5)G)PH2D)N17KC-B500x2
VR102
VR101
VR105
VR104
1
1
1
1
THS-00-00013
THERMISTOR
NTC RESISTOR 50K
FTD5-350
TH1
1
WIR-00-00016
WIRE
WIRE
WIRE
AWG #22 BLACK (3PHI RING LUG)
AWG #14 RED
AWG #14 RED
80m/m
200m/m
190m/m
W1
W2(W2-A, W2-B)
W3(W3-A, W3-B)
1
1
1
TUB-00-00008
TEFLON TUBE
0.7PHI
10m/m
TH1
2
PCB-00-00952
P.C.B
FR-4 SINGLE LAYER, 1Oz (GREEN)
PAS132-01
31x31m/m(REMOTE)
1
VOL-00-00044
RES-00-00668
JAC-00-00050
COD-00-00001
VOLUME
RESISTOR
MODULAR JACK
MODULAR JACK ASS'Y
V9M5720009A
CARBON FILM 1/5WJ
4P
4P(5 METER)
A20Kx2 (9 PHI)
2K OHM
KEK623PCB4-B
LINE CODE (501-64 / 64-5000)
VR701
R701
MOD02
ACEESSORY
1
1
1
1
"NP / BP" (10x16)
"SHL / SD" (10x20)
"SHL / SD" (12x20)
"RX" (16x25)
"HC" (30x25)
V12L5(9x5)G(4R)(PH2D)N15KC-A2Kx2+A200Kx2
12
Power Amplifier
BPX500.1
14
15
16
Power Amplifier
BPX500.1
17
18
19
Ref#
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
19
20
21
22
23
Description
Part Number
Qty
HEAT SINK MAIN AL/EXTRUSION
(L=430mm)
FRONT PANEL EGI 1.2T
REAR PANEL EGI 1.2T
WINDOW ACRYLIC 3.0T
BADGE AL
MOUNTING FOOT ADC-7 DIE CASTING
LENS, ACRYLIC (WITH SILKSCREEN)
LENS, ACRYLIC (WITHOUT SILKSCREEN)
INDICATOR ACRYLIC (CLEAR)
BRACKET TR(A) CR,47 X 15 X 1.5T (NI-P)
BRACKET TR(B) CR,103 X 15 X 1.5T (NI-P)
CUSHION BKT-TR(A) FIBER 43 X 15 X 0.5T
CUSHION BKT-TR(B) FIBER 99 X 15 X 0.5T
CUSHION RUBBER (A) 12 X 7 X 1.6T
SILICON PAD (SP1000) 22 X 0.3T
SUPPORT PCB NYLON L=4.5mm
SWITCH DECAL FELT 12 X 7 X 0.3T
TUBE 5 X 40mm
SCREW STT2 BH 3 X 12 NI-P
SCREW STT2 BH 3 X 8 BK
SCREW SML 3 X 6 NI (NO SERRATION)
SCREW SML 4 X 10 NI-P
SCREW STT1 PH 4 X 25 BK
GAP PAD 25 X 50 X 5
HEA-01-576A0
1
PAN-06-562A0
PAN-06-565A0
COV-22-623B0
BAD-01-515A0
FOO-01-504B0
COV-22-549AA
COV-22-549A0
ILL-22-503A0
BKT-05-519A0
BKT-05-521A0
SUB-28-572A0
SUB-28-574A0
SUB-33-513A0
SIL-34-001A0
SUP-29-502A0
SUB-27-524A0
SUB-12-575A0
SC5-NB-30120
SC5-BB-30080
SC1-NL-30060
SC1-NL-40100
SC4-BP-40250
GAP-00-029A0
1
1
1
1
2
1
1
3
2
3
2
3
1
6
2
3
6
14
8
10
20
2
20
21
22
23
24
25
26
27
28
29
30