Download 750kW Containerized Diesel Generator Set

750kW Containerized
Diesel Generator Set
Model
Emissions
EGC-750DD
EPA Certified
Standby Rating
Prime Rating
60 Hertz
750kW (937.5kVA)
600kW (750kVA)
750 KW
(Shown with 40 ft. container optional ISO trailer chassis)
Standard Features
Detroit Diesel Heavy Duty Diesel Engine
„ 4-cycle design, turbocharged, aftercooled, direct injection
„ Polymide blade cooling fan
„ Engine coolant heater
„ Meets EPA emissions standards for mobile off-highway
Fuel System
„ 1000 gallon, single wall fuel tank
„ Fuel priming system
„ Fuel/water separators and drip pan
„ Electric fuel pump
„ External fuel fill
„ 30 micron Racor® fuel filter system
Alternator
„ Brushless, 4-pole, synchronous, WYE connection
„ Class H insulation system conforms to NEMA MG1-22, BS5000,
CSA-C22-2, IEC-34-1 standards for temperature rise
„ Drip-proof, self-venting, amortisseur windings
„ Epoxy impregnated windings with tropical insulation for increased
environmental protection and long life
Electronic Voltage Regulator
■ Electronic automatic voltage regulator provides precise regulation
■ Separate three-phase excitation for fast recovery from block loads
and motor starting
Full Load Acceptance
„ Accepts 100% of standby nameplate rating in one step, in compliance
with NFPA, para 5-13.2.6
Generator Control Panel
„ InteligenTM vibration-isolated controller
„ Manual or remote engine start/stop
„ RS232/Modbus communication support
„ Safety shutdowns
„ Externally mounted emergency stop switch
„ Generator mainline circuit breaker, 100% rated electronically
operated, UL listed
Specially Designed Container
■ 40 ft. ISO container, sound-attenuated, foam-lined for extremely
quiet operation
■ Isolated operator control room
„ Solidly mounted battery rack and cooling system
„ Intregral vibration isolators
„ Exterior polyurethane coating system provides long life in extreme
operating conditions
„ Interior DC lights and timer switch
„ Critical grade silencer with heat blankets
„ Electrically operated roof mounted air intake vent doors
Warranty
„ Engine-generator sets are covered by an express written, one-year
limited warranty
750kW Containerized
Diesel Generator Set
APPLICATION DATA
Alternator Specifications
Make
Type
Number of Leads
Generator Type
Voltage Regulator
Insulation
Material
Temperature Rise
Bearing: Number, Type
Coupling
Amortisseur Windings
Voltage Regulation (no load to full load)
One Step Load Acceptance % of rating per NFPA-110
Peak Motor Starting HP
Generator Efficiency at Full Load
Phase Sequence
L-L Harmonic Max Total
L-L Harmonic Max Single
Voltage Dip Upon Full Load Application (1 Step)
Voltage Rise Upon Full Load Rejection (1 Step)
Marathon Magna Max
4-Pole, Rotating Field
10 or 12
Rotating Field; PMG
Solid State, Digital, Model DVR2000
NEMA MG1-1.66
Class H
Standby Rating: 125o C
Prime Rating: 105o C
Single, Sealed
Flexible Disk
Full
2% Maximum
100
500
95%
ABC (L1, L2, L3)
5.0%
3.0%
20% for 1.6 sec.
10% for 0.6 sec.
Engine Specifications
Manufacturer/Model
Detroit Diesel/MTU 12V2000-G81
4-cycle, Turbocharged,
Type
Air to Water Aftercooled
Cylinder Arrangement
V-12
Displacement
1458 in3 (23.9 liter)
Bore
5.12 in. (130 mm)
Stroke
5.91 in. (150 mm)
Compression Ratio
14.5:1
Piston Speed (60Hz)
29.5 ft./sec. (9.0 m/sec)
Bearing Main Number/Type
7, Replaceable, Precision
Cylinder Block
Cast iron
Cylinder Head Material
Cast iron
Crankshaft Material
Forged steel
Valves
Dual, Poppet Type
Brake Mean Effective Pressure (BMEP)
338 psi (2330 kPa)
Rated RPM (60 Hz)
1800 RPM
Max. Power At Rated RPM (with fan)
1120 hp (835.2 kW)
Governor Type
Electronic
Frequency Regulation: No load to full load
Isochronous
Frequency Regulation: Steady State
+0.25 Hz
Air Cleaner Type - All Models
Dry, Dual Element
The 750 KW Sound Attenuated Generator includes a
reconnectable 10 or 12 lead generator that is configured for
standard 60 Hz, 480V or 208V output. Special voltage outputs
are available.
Alternator Features
■ All ratings tested per MIL-STD-705 as applicable.
■ Generator protection for overload and short circuit.
■ Generator is designed and built within NEMA, IEEE and
ANSI standards for temperature rise.
■ PMG exciter for superior regulation and response.
■ Three phase sensing on regulator with EMI protection.
■ Skewed rotor for smooth voltage wave form.
■ Vacuum impregnated epoxy varnish - Fungus resistant per
MIL-I-24092.
■ Sustain short circuit current at 300% of rated current up to
10 seconds.
Amperage
Voltage
Phase
120/208
277/480
3
3
Power
Factor
0.8
0.8
Continuous Amperes
Standby
Prime
2602
2082
1128
902
Engine Electrical System
Battery Charging Alternator Ground Type
Volts
Ampere Rating
Starter Motor Rated Voltage
Minimum Recommended Battery for
0 °C / Cold Cranking Performance
Negative
24 VDC
70A
24 VDC
700 CCA
Exhaust System
Exhaust Temperature at Rated kW
(Dry Exhaust)
Exhaust Flow at Rated kW
Silencer Type
Maximum Allowable Backpressure
Exhaust Outlet Size at hook-up
915 oF (491 oC)
6370 cfm (180.4 m3/min)
Critical
40.8 in/wc (10.0 kPa)
Dual 5.0 in. (127 mm)
750kW Containerized
Diesel Generator Set
Cooling System
Exhaust Manifold Type
Radiator Design
Coolant Capacity - Engine Only
Coolant Capacity - Engine and Radiator
Water Pump Design/Type
Coolant Flow
Heat Rejection to Coolant
Fan Horsepower
Dry
Standard horizontal discharge
17.5 gal. (66 L)
66.5 gal (252 L)
Belt Driven, Centrifugal
89 gal/min (337 L/min)
19625 BTU/min (344.8 kW)
56.0 hp (42 kW)
Thermostat
Inteligen Digital Genset Controller
185 °F (82 °C)
Digital Controller Features
Fuel System
Recommended Fuel
ASTM-D975/No.1 or No.2-D
Fuel Pump Maximum Lift
6.8 ft. (2.1 m)
Filter Micron Size
2
Total Fuel Flow
280 gal./hr. (1061 L/Hr.)
Fuel Consumption
Diesel @ % of load
gal/hr
L/hr
25%
15.2
57.5
50%
26.9
101.8
75%
39.4
149.1
100%
54.7
207.1
Lubrication System
Type
Oil Filters
Oil Pan Capacity
Oil Capacity with Filters
Oil Pressure at Rated Speed
Full Pressure System
3 Spin-on Full Flow
18.0 gal. (69.0 L)
25.0 gal. (94.1 L)
100 - 130 psi (690 - 896 kPa)
Derating (60Hz)
Ambient
The engine power available up to 3300 ft.
Altitude
Temperature
an d 77°F a t stand by r ating, w ithout
derating. Maximum altitude capability is
7500 ft. For operation at higher altitudes Above 3300 ft. Above 77°F,
and ambient temperatures, the power derate at 1.5% derate 0.4%
sh ou ld b e d er a te d a cco r d in g to th e per 1000 ft.
per 10°F
following factors:
■
■
■
■
■
■
■
■
■
■
■
■
■
■
■
■
■
■
■
■
■
■
■
■
■
■
■
■
Large graphic back-lit LCD display 128x64 pixel resolution
Automatic and manual starting and stopping
Phase sequence supervision
Automatic shutdown/alarm function
Input frequency 50-60 Hz
Parameters adjustable via PC or iG keyboard
Predefined and user definable configurations available.
One configuration includes set of inputs/outputs and parameters
Adjustable parameters for each configuration
6 LED indicators
Push buttons for simple control
4 programmable outputs (out of 20 functions selection)
4 binary configuration inputs
Lamp test during start up
Real time clock
Sealed membrane panel to IP65
180 x 113 mm front panel mounted case
Speed measurement from magnetic pickup
Oil pressure, Coolant temperature, Battery voltage and Fuel level
measurements
Running Hour Meter
All Generator metering, kVAr, kW, V1-V3, Hz, I1-I3, kWh, kVAh
Generator under/over voltage alarm/shutdown
Generator under/over frequency alarm/shutdown
Over Current alarm/shutdown
Warm up and cooling functions
Pre-lubrication function with timers
Adjustable crank attempts
Data logging
Remote communications (RS232/Modbus)
750kW Containerized
Diesel Generator Set
Optional Features and Accessories
Generator Set
Container
„ Genset-to-Genset Paralleling Control System
„ ISO Trailer Chassis (40 ft.)
„ Base Load-to-Utility Paralleling Control System
„ Double-wall Fuel Tank (900-gallon capacity)
„ Custom Outlet Panels
„ Fluid Containment
„ Rotary Voltage Selector Switch (High Wye/Low Wye
Voltages)
„ Manual Fuel Valves (For Internal or External Fuel
Supply)
„ Auxiliary Oil Reservoir with Level Control (15-gallon)
„ Entrance Ladder (6-Step, Aluminum Construction)
„ Centrifugal Oil Filter System
„ Fueling Ladder (Aluminum Step Construction with
Hand Rail)
„ Oil Pan Heater with Thermostat
„ Interior Lights (AC Work lights)
„ Alternator Strip Heater
„ AC Battery Charger with Shore Power Receptacle
„ Custom Paint Colors (Artic White is Standard)
SPECIAL OPTIONS AVAILABLE UPON REQUEST
40 ft Container
Weight and Dimensions
A
B
C
D
96 in.
(2,438 mm)
480 in.
(12,192 mm)
163 in.
(4,137 mm)
199 in
(5,054 mm)
Weight (Wet)*
37,540 lbs (17,030)
Weight (Wet with trailer)*
44,280 lbs (20,085 kg)
* Weight is approximate. Wet weight does not include fuel.
Backfeed to a utility system can cause electrocution and/or property damage. Do not
connect to any building’s electrical system except through an approved device.
Specifications are subject to change without notice.
Your MQ Power dealer is:
MQ POWER
POST OFFICE BOX 6254
CARSON, CA 90749
310-537-3700 • 800-421-1244
FAX: 310-632-2656
E-MAIL: [email protected]
WEBSITE: www.mqpower.com
© COPYRIGHT 2007, MQPOWER
Rev. 2 (03-07) EGC750DD