Download sara title iii - American Niagara

MATERIAL SAFETY DATA SHEET (M.S.D.S.)
PRODUCTS MANUFACTURED BY:
AMERICAN NIAGARA
• 6690 JONES MILL COURT • SUITE "A" • NORCROSS, GA 30092
PH: (770) 441-5900 • TOLL FREE (800) 241-7708 • FAX (770) 409-7240
24 HOUR EMERGENCY
800-424-9300 CHEMTREC
PRODUCT MANUFACTUREDFOR (IF DIFFERERENT FROM ABOVE)
AMERICAN NIAGARA CORPORATION
*SEE ABOVE
SECTION I
PRODUCT IDENTIFICATION
TRADE NAME
CHEMICAL NAMES & SYNONYMS
HIGH TEMPERATURE PALLET ADHESIV E FOR
SCREEN PRINT ERS
SECTION II
VIPER FLASH ADHESIVE
HAZARDOUS INGREDIENTS WITH CAS #'S & WEIGHT BY % (DOES NOT INCLUDE NON-HAZARDOUS)
INGREDIENTS THAT ARE APPLICABLE
CYCLOHEXANE
HEXANE
ISOBUTANE/PROPANE BLEND
CAS NUMBERS THAT ARE APPLICABLE
CAS 110-82-7
CAS 110-54-3
CAS 75-28-5
CAS 74-98-6
CAS 142-82-5
CAS 67-64-1
HEPTANE
ACETONE
% BY WEIGHT
PEL-300
PEL-50
PEL 800
PEL 1000
PEL 500
PEL 1000
TLV-300
TLV-50
TLV 800
TLV 1000
TLV 400
TLV 750
SECTION IIA CHEMICAL RATING SYSTEM
CHEMICAL RATING SYSTEM WHEN APPLICABLE / NFPA (NATIONAL FIRE PROTECTION AGENCY) - PRODUCTS ARE GRADED FROM 0 TO 4 ON (H) HEALTH,
(F) FLAMMABILITY, AND (R) REACTIVITY. 0 = NO SPECIAL HAZARD; 1 = SLIGHT; 2 = MODERATE; 3 = HIGH; 4 = EXTREME. THE INFORMATION FOR THIS PRODUCT IS AS
FOLLOWS (*NOTE MAY NOT BE APPLICABLE ON CERTAIN TYPES OF PRODUCTS)
H =2
SECTION III
F= 4
R= 0
PHYSICAL DATA
VAPOR DENSITY N/E
BOILINGPOINT(F)
N/A
SPECIFIC GRAVITY (WATER = 1)
1.05
VAPOR PRESSURE
EVAPORATION RATE (ETHER = 1)
@70O C MAX 60
(N-BUTYL ACETATE = 1
SOLUBILITY IN WATER
APPEARANCE AND ODOR
PARTIAL
OFF WHITE,VISCOUSLIQUID WITH ETHER-LIKE ODOR.
SECTION IV
FIRE & EXPLOSION HAZARD DATA
FLASH POINT (METHOD USED)
FLAMMABLE LIMITS / LOWER / UP[PER
-156OF (TCC)
EXTINGUISHING MEDIA
DRY CHEMICAL, FOAM OR CO2
SPECIAL FIRE FIGHTING EQUIPMENT
WEAR SELF-CONTAINED BREATHING APPARATUS. KEEP CONTAINERS COOL WITH WATER FOG TOPREVENT BURSTING.
UNUSUAL FIRE AND EXPLOSION HAZARDS
RUPTURED CONTAINERS MAY "ROCKET OUT OF LOCALIZED AREA,CAUSING INJURYAND SPREAD OF FIRE.
SECTION V
REACTIVITY DATA
STABLE
STABILITY
XX
UNSTABLE
CONDITIONS TO AVOID
SOURCES OF EXTREME HEAT
STABILITY
INCOMPATIBILITY: (SPECIFIC MATERIALS TOAVOID
STRONG OXIDIZERS, ALUMINUM METAL
HAZARDOUSDECOMPOSITION
CO, CO2 Hcl AND TRACES OF PHOSGENE
HAZARDOUSPOLYMERIZATION
WILL NOT OCCUR
SARA TITLE III
HEXANE (CAS 110-54-3)
HMIS HEALTH 2 FLAMMABILITY 4 REACTIVITY 0
NFPA HEALTH 2 REACTIVITY 0 FIRE 4 SPECIAL 0
0 = MINIMAL 1 = SLIGHT 2 = MODERATE
3 = SERIOUS 4 = SEVERE
MATERIAL SAFETY DATA SHEET (M.S.D.S.) * PAGE #2
AMERICAN NIAGARA
• 6750 JONES MILL COURT • SUITE "E" • NORCROSS, GA 30092
PH: (770) 441-5900 • TOLL FREE (800) 241-7708 • FAX (770) 409-7240
24 HOUR EMERGENCY
800-424-9300 CHEMTREC
PRODUCT NAME:
VIPER FLASH ADHESIVE
SECTION VI
HEALTH HAZARD INFORMATION
EYE
( ACUTE)
SEVERE EYE IRRITATION.
SKIN CONTACT
Wash exposed skin w ith soap and w ater. Wash contaminated clothing before reuse.
SKIN ABSORPTION
YES
INGESTION
YES
INHALATION
YES
SYSTEMIC & OTHER EFFECTS
INHALATION:DIZZINESS, WEAKNESSAND EVEN DEATH IF EXPOSURE ISSEVERE. EYES& SKIN: SEVERE IRRITATION.
EMERGENCY & FIRST AID PROCEDURES
EYE & SKIN
EYE: FLUSH WITH WATERFOR 15MINUTES. CALL PHYSICIAN IFIRRITATION PERSISTS. SKIN: WASH WITH SOAP AND WATER.
INHALATION
REMOVE TO FRESH AIR. GIVE OXYGEN IF BREATHING IS DIFFICULT. GETMEDICAL ATTENTION.
INGESTION
INDUCE VOMITING. GETMEDICAL ATTENTIONIMMEDIATELY. NEVERGIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
NOTE TO PHYSICIAN
HAS BEEN SUGGESTED TO CAUSE CARDIAC ABNORMALITIES, LIVER, KIDNEY ANDLUNG DAMAGE.
SECTION VII SPILL & DISPOSAL PROCEDURES
SMALL LEAKS
ELIMINATE SOURCES OF IGNITION, VENTILATE AREA.SOAK UP ABSORBANT MATERIAL.
LARGE SPILLS
AFTER LIQUIDHAS EVAPORATED,DISPOSE IN APPROVED LANDFILLOR OTHER IN ACCORDANCE WITH STATE,LOCAL AND FEDERAL REGULATIONS
DISPOSAL METHOD
IN ACCORDANCE WITH ALL LOCAL,STATE ANDFEDERAL REGULATIONS.
SECTION VIII SPECIAL PROTECTION INFORMATION
RESPIRATORY:
WEAR SELF -CONTAINED BREATHING APPARATUS
EYE
SAFETY GOGGLES OR FACE SHIELD
SKIN
RUBBER GLOVES TO CLEAN SPILLS
OTHER
SECTION IX
SPECIAL PRECAUTIONS
HANDLING & STORAGE
ELIMINATE SOURCES OF IGNITION, VENTILATE AREA.WELL.
OTHER
DISCLAIMER
THE INFORMATION CONTAINED IN THISMATERIAL SAFETY DATA SHEET ISPROVIDEDPURSUANT TO 29CFR 1910.1200 TO CONVEY INFORMATION CONCERNING THE
HAZARDOUS NATURE OF THENAMEDPRODUCT.
THE INFORMATION SUPPLIED WAS COMPILED FROM THE MOST RELIABLE SOURCES AVAILABLE AT THE TIME OF PREPARATION AND INLIGHT OF THE MOST
REASONABLEFORSEEABLE EXPOSURE SITUATIONS EXPECTED FROM THE INTENDED USE OF THIS PRODUCT. THE MATERIAL MAY PRESENT GREATER OR LESSER
HAZARD EXPOSURE UNDER OTHER CIRCUMSTANCES THAT ARE BEYOND THE CONTROL OF THE MANUFACTURER. FOLLOW ALL DIRECTIONSAND WARNINGS ON
THE PRODUCT LABEL.
DATE: 10-08